Door popping open
Moderators: hot66, impmad2000, Nige
Door popping open
Hello,
Have a frustrating and potentially dangerous problem with my passenger door.
It's a swine to shut properly and I have had to result in forcing it into the shut position by leaning heavily on the door and giving it a shove. (the seals and gaps etc are fine, so I can't see any obstruction or problem with the hinges).
OK, passenger in and door locked. Problem solved? No. Every time I hit a big rut in the road (unavaoidable in London I'm afraid) the door pops to the semi-closed position. It has been known to open completely.
Any pointers?... It seems to me that the turning catch affixed to the door is loose and won't lock properly. Is that fixable or will I need to replace?
Any advice gratefully received.
Best regards,
Will
Have a frustrating and potentially dangerous problem with my passenger door.
It's a swine to shut properly and I have had to result in forcing it into the shut position by leaning heavily on the door and giving it a shove. (the seals and gaps etc are fine, so I can't see any obstruction or problem with the hinges).
OK, passenger in and door locked. Problem solved? No. Every time I hit a big rut in the road (unavaoidable in London I'm afraid) the door pops to the semi-closed position. It has been known to open completely.
Any pointers?... It seems to me that the turning catch affixed to the door is loose and won't lock properly. Is that fixable or will I need to replace?
Any advice gratefully received.
Best regards,
Will
have you adjusted your door shuts?? i had the same problem when putting mine together justtakes a bit of patience to get right
COMPUTER GAMES DONT AFFECT KIDS,I MEAN IF PACMAN AFFECTED MY GENERATION AS KIDS, WE WOULD HAVE ALL BE RUNNING AROUND IN THE DARK LISTENING TO REPETITIVE MUSIC MUNCHING PILLS
took a look last night...
can't see any way of making an adjustment up or down. the latch affixed to the body is held in place by two allen key bolts which, it would seem, only allow for horizontal movement...could making a horizontal adjustment (using washers, i assume) solve the problem?
can't see any way of making an adjustment up or down. the latch affixed to the body is held in place by two allen key bolts which, it would seem, only allow for horizontal movement...could making a horizontal adjustment (using washers, i assume) solve the problem?
'72 2.4S Targa
hi will it will go in all directions just loosen it and move around till you get it right
make sure its the catch on the body work NOT THE DOOR
good luck
make sure its the catch on the body work NOT THE DOOR
good luck
COMPUTER GAMES DONT AFFECT KIDS,I MEAN IF PACMAN AFFECTED MY GENERATION AS KIDS, WE WOULD HAVE ALL BE RUNNING AROUND IN THE DARK LISTENING TO REPETITIVE MUSIC MUNCHING PILLS
Cheers Miggs, I follow you...
Seen this suggestion on the Pelican Parts site for a handy tip in lining up the latch>>
The best way to adjust (in and out) is to losen those bolts with the proper tool, until the plate can move around, but not too lose to where it's sloppy. Then gently close the door while holding the trigger in, so that it doesn't latch. Then gently push on the door handle until the door edge lines up with the body to your liking. Then while continuing to hold the trigger in, gently open the door and tighten the plate where it is. I hold it slightly; pushing against it so it doesn't move while you're tightening the bolts.
Seen this suggestion on the Pelican Parts site for a handy tip in lining up the latch>>
The best way to adjust (in and out) is to losen those bolts with the proper tool, until the plate can move around, but not too lose to where it's sloppy. Then gently close the door while holding the trigger in, so that it doesn't latch. Then gently push on the door handle until the door edge lines up with the body to your liking. Then while continuing to hold the trigger in, gently open the door and tighten the plate where it is. I hold it slightly; pushing against it so it doesn't move while you're tightening the bolts.
'72 2.4S Targa
Think I need a new pair of latch plates.
Carried out adjustment as suggested. Managed to reduce the tension on the latch which eased the popping open problem, but did not cure it.
The hard plastic that is meant to guide the catch attached to the door into lock position has disintegrated. Can you buy replacement plastic or is this a case of needing new latch plates?
Cheers,
Will
Carried out adjustment as suggested. Managed to reduce the tension on the latch which eased the popping open problem, but did not cure it.
The hard plastic that is meant to guide the catch attached to the door into lock position has disintegrated. Can you buy replacement plastic or is this a case of needing new latch plates?
Cheers,
Will
'72 2.4S Targa
Hi,
Fitted a new striker plate, but can't seem to get it into a good position. The door closes nearly flush, but the popping open is still a problem...especially on left hand bend with badly placed pot holes...I'm terrified of it swinging open into an on coming car.
Anyone got any pointers that might at least help me keep the door closed until I can get someone to have a proper look at it?
Any help much appreciated.
Will
Fitted a new striker plate, but can't seem to get it into a good position. The door closes nearly flush, but the popping open is still a problem...especially on left hand bend with badly placed pot holes...I'm terrified of it swinging open into an on coming car.
Anyone got any pointers that might at least help me keep the door closed until I can get someone to have a proper look at it?
Any help much appreciated.
Will
'72 2.4S Targa
its a pity you wasnt a bit closer i would have a look for you
im sure someone in your area might be able to help put where you are from on your profile so you never know there might be some ddk members in your area who can help
im sure someone in your area might be able to help put where you are from on your profile so you never know there might be some ddk members in your area who can help
COMPUTER GAMES DONT AFFECT KIDS,I MEAN IF PACMAN AFFECTED MY GENERATION AS KIDS, WE WOULD HAVE ALL BE RUNNING AROUND IN THE DARK LISTENING TO REPETITIVE MUSIC MUNCHING PILLS